Design of an irradiation rig using screen method for silicon transmutation doping at the Dalat research reactor
Main Article Content
Abstract
The neutron transmutation doping of silicon (NTD-Si) at research reactors has been
successfully implemented in many countries to produce high-quality semiconductors. In the late 1980s, NTD-Si has been tested at the Dalat Nuclear Research Reactor (DNRR) but the results have been limited. Therefore, the design and testing of an irradiation rig for NTD-Si at the DNRR are necessary to have a better understanding in order to apply the NTD-Si in a new research reactor of the Research Centre for Nuclear Science and Technology (RCNEST), which has planned to be built in Viet Nam. This paper presents the design and testing of a new irradiation rig using screen method for testing NTD-Si at the DNRR. The important parameters in the rig such as neutron spectrum and thermal neutron flux distribution were determined by both calculation using MCNP5 computer code and experiment. The aluminum ingots, which have similar neutronic characteristics with silicon ingots, were irradiated in the rig to verify the appropriate design. The uniformity of thermal neutron flux in the rig is less than 5% in axial and 2% in radial directions, respectively. However, the thermal/fast flux ratio of the irradiation rig is 4.38/1 would affect target resistivity of testing Silicon ingots after irradiation.
Article Details
Keywords
NTD-Si, MCNP5, Dalat Nuclear Research Reactor (DNRR), screen method, foil activation, irradiation rig
References
[2]. Phan An et al., “Research on using neutron of the Dalat Nuclear Research Reactor for doping single silicon crystals used in semiconductor components”, Report in Vietnamese, Z181, 1988.
[3]. Dalat Nuclear Research Institute, “Safety Analysis Report”, 2012.
[4]. International Atomic Energy Agency, “Regional Training Course on calculation and measurement of neutron flux spectrum for research reactors”, Serpong, Indonesia, 1993.
[5]. X-5 Monte Carlo Team, “MCNP, A General Monte Carlo N-Particle Transport Code, Version 5", Los Alamos National Laboratory report LA-UR-03-1987, April 2003.
[6]. M. B. Chadwick et al., “ENDF/B-VII.0: Next Generation Evaluated Nuclear Data Library for Nuclear Science and Technology", Nuclear Data Sheets, 107, 2006.
[7]. Dalat Nuclear Research Institute, “Lookup table of excess reactivity of the Dalat Nuclear Research Reactor”, Internal Report in Vietnamese, 2018.
[8]. Dalat Nuclear Research Institute, “Experiment and calculation results on the designed irradiation rigs for testing NTD-Si”, Internal Report in Vietnamese, 2018.
[9]. International Atomic Energy Agency, “Silicon Transmutation Doping Techniques and Practices”, Proc. IAEA Consultants Mtg, Otwock-Świerk, Poland, 1985.
[10]. Dalat Nuclear Research Institute, “Operational Workbook of the Dalat Research Reactor”, Workbook in Vietnamese, 2018.